Wilbur Curtis Company ALPHA 2X Wartungshandbuch PDF herunterladen

Models Included

 •ALPHA1GT

 •ALPHA2GT

 •ALPHA2GTW

 •ALPHA3GT

 •ALPHA3GTR

 •ALPHA3GTL

 •ALPHA4GT

 •ALPHA5GT

 •ALPHA5GTR

 •ALPHA5GTL

 •ALPHA6GT

 •ALPHA6GTN

CAUTION:DONOT

connect this brewer to hot

water.Theinletvalveis

not rated for hot water.

CAUTION:Pleaseuse

this setup procedure

before attempting to use

this brewer. Failure to follow the

instructions can result in injury or the

voidingofthewarranty.

ISO9001REGISTERED

Important Safeguards/Conventions

Service Manual, Alpha G3 - Decanter Brewer

For the Latest speciFications and inFormation go to www.wiLburcurtis.com

This appliance is designed for commercial use. Any servicing other than cleaning and maintenance should be performed by an autho-

rized Wilbur Curtis service center.

 •DoNOTimmersetheunitinwateroranyotherliquid

 •Toreducetheriskofreorelectricshock,doNOTopentoporrearpanel.Nouserserviceablepartsinside.Repairshould 

be done only by authorized service personnel.

 •Keephandsandotheritemsawayfromhotpartsofunitduringoperation.

 •Nevercleanwithscouringpowders,bleachorharshimplements.

Conventions

WARNINGS–Tohelpavoidpersonalinjury

ImportantNotes/Cautions–fromthefactory

SanitationRequirements

YourCurtisADSSystemisFactoryPre-SetandReadytoGo…RightfromtheCarton.

FollowingaretheFactorySettingsforyourALPHA™GT

CoffeeBrewingSystems:

•BrewTemperature=200°F

 •BrewVolume=Settodispensingvesselrequirements(60oz)

 •WarmerSettingonHIGHwithQualityTimerOFF

GenerallytherewillneverbeareasontochangeyourG3programming.However,shouldyouneedtomakeslightadjustmentstomeet

yourbrewingneeds,programminginstructionsareprovidedlaterinthismanual.

 SystemRequirements:

  •WaterSource20–90PSI.Musthaveaminimumowrateof½GPM(preferredowrateis1gpm).

  •Electrical:Seeattachedschematicforstandardmodelorvisitwww.wilburcurtis.comforyourmodel.

Equipmenttobeinstalledtocomplywithapplicablefederal,state,orlocalplumbing/electricalcodeshavingjurisdiction.

SETUPSTEPS

Theunitshouldbelevel(lefttorightandfronttoback),locatedonasolidcountertop.Connectawaterlinefromthewaterltertothe

brewer.NOTE:Sometypeofwaterltrationdevicemustbeusedtomaintainatrouble-freeoperation.(Inareaswithextremelyhard

water,wesuggestthatasedimentaryandtaste&odorlterbeinstalled.)Thiswillprolongthelifeofyourbrewingsystemandenhance

coffeequality.

1.A3/8”NPTx1/4”Flareelbowhasbeensuppliedforwaterlineconnection.Usetubingsizedsufcientlytoprovideaminimumof 

½ gallon per minute.

2.Connecttheunittoanappropriateelectricalpowercircuit.

3.Turnonthetoggle(STANDBY/ON)switchbehindtheunit.Theheatingtankwillstarttoll.Whenthewaterlevelinthetankrises 

tothecorrectvolume,theheatingelementswillenergizeautomatically.WithADSSystemsthereisnodangerofelementburnout 

causedbyanemptytank.

4.Theheatingtankwillrequire20to30minutestoreachoperatingtemperature(200°F)asindicatedbyREADY-TO-BREWdisplayed

ontheLED.

5.Priortobrewing,dispense12ouncesofhotwaterthroughthehotwaterfaucet.

6. Brewacycleofatleast12ounces,topurgethewaterlinesofanyairthatmaybetrappedafterlling.

BREWINGINSTRUCTIONS

 1.BrewershouldbeON(Conrmatreartoggleswitch,thenpressON/OFFbutton).Ready-to-Brewshouldbedisplayed.

 2.Placeemptydecanter(notincludedwithAlphabrewer)onwarmerplate.

 3.Placeanewlterinbrewcone.

4.Pourground

coffee into

  brewcone.

6. PressBrew

button.

Wi l b u r Cu r t i s Co m p a n y , in C .

5. Position

 brewcone

 intobrew

rails.

WILBURCURTISCOMPANY

Montebello,CA90640

CAUTION:When

cleaning,DONOTuse

powders, liquids, cleans-

ers, or any substance containing

chlorine.Theseproductspromote

corrosion, cause pitting of

stainlesssteelandwillvoidthe

warranty.

NSF International requires the following water connection:

1. Aquickdisconnectoradditionalcoiledtubing(atleast2xthedepthoftheunit)sothatthemachinecanbemovedfor 

cleaning underneath.

2. Insomeareasanapprovedbackowpreventiondevicemayberequiredbetweenthebrewerandthewatersupply.

Fi n d o u t m o r e

o n t h e w e b

www.wilburcurtis.com

1 2 3 4 5 6 7 8

Inhaltsverzeichnis

Seite 1 - t h e w e b

1Models Included •ALPHA1GT •ALPHA2GT •ALPHA2GTW •ALPHA3GT •ALPHA3GTR •ALPHA3GTL •ALPHA4GT •ALPHA5GT •ALPHA5GTR

Seite 2 - PROGRAM MENUS

32Brew VolumeSelectingBrewbyVolumeorBrewbyTimedependsonwhetheryouknowyourbrewtimebeforestarting.FromProgramMenuspress>displa

Seite 3

32Cold Brew Lock . . . (Factory set to 15º)Presstoselect,<or>toselectdesiredsetting(CBL5,15orOFF), to set. TheColdBrew

Seite 4 - ALPHA GT

54ILLUSTRATED PARTS LISTALPHA GTITEM PART Nº DESCRIPTION 1 WC-58117 COVER, TOP ALP1/ALP3GTL/ALP3GTR/ALP5GTW 1A WC-58019 COVER, TOP ASSY ALP2GT

Seite 5 - VIEWEDFROM

54Alpha1GTModelShown,OtherModelsIdenticalExceptWhereNoted.232312AILLUSTRATED PARTS LISTALPHA GT123574691081114122714A14B211715162219182472013

Seite 6 - ELECTRICAL SCHEMATIC

76ELECTRICAL SCHEMATIC

Seite 7

ALP1GTALP2GT76VARIETY OF ALPHA GT BREWERSALP1GT ALP2GT ALP2GTWALP3GT ALP3GTLALP3GTRALP4GT ALP5GTALP5GTLALP5GTR ALP6GTALP6GTN

Seite 8 - Product Warranty Information

98FOR THE LATEST SPECIFICATION INFORMATION GO TO WWW.WILBURCURTIS.COMPrinted in U.S.A. 7/09 F-3216-S rev QWILBUR CURTIS CO., INC.6913AccoSt.,